Results 1 to 5 of 5

Thread: 89 csx wont start

  1. #1
    Garrett booster
    Join Date
    Apr 2009
    Location
    Gardner, Kansas
    Posts
    130

    89 csx wont start

    As the title states I have an 89 csx that won't start. Mice got into the engine bay and chewed up the harness. It did run but not very well obviously. I recently installed a new harness from a running car. The fuel pump will turn on but I'm not getting any cranking. Is there a way to test the relays under the hood on the drivers side or a way to test the start relay on the steering column? Any help would be greatly appreciated.thanks!!

  2. #2
    Supporting Member Turbo Mopar Contributor
    Join Date
    Feb 2015
    Location
    toronto
    Posts
    1,765

    Re: 89 csx wont start

    Do you have the FSM? NAJ has a good no start procedure on TD. If you can't find it LMK. Also a factory powertrain troubleshooting manual is also of value here.

    use site specfic google searches is very powerful for example type " naj no start site:www.turbododge.com"

    Here is one search result----

    Re: No Crank / No Start
    So you may have more than one issue or they may both be related.
    Start with the "Will Not Crank" problem.

    1)Battery is Fully Charged and Holds a Load.
    2)Battery Terminals and Posts are Clean, Free of Corrosion and Tight.
    3)Battery Cables are Tight on the Engine Block and Starter
    4)Small Starter Wire is Tight On the Starter.
    5)If ALL of that checks OK
    6)When the Car will Not Crank and you get Nothing when turning the key to the "Start" position verify all Power is present at the Starter Relay.
    a)Red, Constant Battery Power From the Battery through a Fusible Link.
    b)Yellow, Switched Ignition Power from the Ignition Switch
    Power will only be present with the key in the "Start" position.
    c)Brown/Yellow, Ground
    a)Bolted to Transaxle on a Manual Trans
    b)Through Neutral Safety Switch on Auto Trans.
    4)Brown, Power Out to the Starter

    You may want to Physically Inspect the Ignition Switch and Connector for Damage/Looseness, etc.
    With the Engine Running Perform a Wiggle Test on the Ignition Switch Connector to see if you can Duplicate the Problem of the Car Shutting Off.
    Regards,
    Miles

    DD '87 Sundance T1, SLH with rear disks
    '87 CSX #432 2.5 CB TII, SLH

  3. #3
    Garrett booster
    Join Date
    Apr 2009
    Location
    Gardner, Kansas
    Posts
    130

    Re: 89 csx wont start

    Awesome thank you,I'll verify all that and check back in

  4. #4
    Garrett booster
    Join Date
    Apr 2009
    Location
    Gardner, Kansas
    Posts
    130

    Re: 89 csx wont start

    After 4 years of sitting and mice chewing up the engine harness,it lives! Traced the no start back to a broken brown/yellow ground wire. It fired up on the first try!Thanks for the help. Now to get it road worthy again

  5. #5
    Supporting Member Turbo Mopar Contributor
    Join Date
    Feb 2015
    Location
    toronto
    Posts
    1,765

    Re: 89 csx wont start

    Quote Originally Posted by kcvrodder View Post
    After 4 years of sitting and mice chewing up the engine harness,it lives! Traced the no start back to a broken brown/yellow ground wire. It fired up on the first try!Thanks for the help. Now to get it road worthy again
    Excellent news!!
    Regards,
    Miles

    DD '87 Sundance T1, SLH with rear disks
    '87 CSX #432 2.5 CB TII, SLH

Similar Threads

  1. Car wont start, PM/ASD?
    By 1966 dart wagon in forum "I need help!"
    Replies: 7
    Last Post: 05-28-2016, 02:15 PM
  2. car wont start
    By slamer283 in forum "I need help!"
    Replies: 4
    Last Post: 01-03-2013, 11:32 AM
  3. car wont start
    By 663csx-t in forum "I need help!"
    Replies: 17
    Last Post: 02-06-2010, 01:49 PM
  4. wont start??
    By 89boostedminivan in forum "I need help!"
    Replies: 1
    Last Post: 10-16-2008, 10:15 AM
  5. Why wont my car start?
    By shelbyplaya in forum Electrical & Fuel System
    Replies: 5
    Last Post: 10-03-2008, 07:49 PM

Tags for this Thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •