Hey Guys I decided I should do a project log for my van, as it hasn't been seen much on here.
1989 Plymouth Voyager, currently with 150k miles. I purchased it from the original owner in 2012 with 112k miles. Bought as a rust free, clean title, garaged Colorado van.
Current Photo:
Current Stats:
Engine:
-Stock 2.5 shortblock, reringed/ new main/rod bearings at ~140k miles.
-Balance shaft case gutted, oil hole plugged.
-Oil pickup enlarged
-3" custom intake to turbo with 9" cone filter
-52mm throttle body
-Treadstone TRV1859 720hp intercooler/ 2.5" piping
-TurboXS RFL Blow off valve
-Crazyeye reworked 1 piece intake
-portmatched and deshrouded valve swirl head
-Felpro headgasket, Mopar performance head bolts
-Comp cams 26995 valve springs and 774 retainers
-PT cruiser lifters/shims
-turbosunleashed ported exhaust manifold
-46 trim T3/T4 with stage 1 .63 turbine, ported compressor housing
-2.5" swingvalve ported to 2.8"
-3" downpipe to electric cutout before cat. Stock exhaust catback.
-Underdrive pulley/belts
-Poly front motor mount, poly filled side/trans mounts
-Custom catch can setup
-180* thermostat, new radiator in 2015, replaced all hoses
-1992 caravan radiator fan/ manual radiator fan switch
Transmission:
-Swapped a413 to a523
-1991 big input shaft 3.50 a523, refreshed in 2014 with new seals, diff bearings, diff pin retainers, and preloads set.
-running Redline MT-90 oil
-TU stage III 6 puck ceramic clutch with ~3k miles.
-Polyurethane bobble strut mount
-Rebuilt factory Mopar axles
Electronics:
-Autometer Analog wideband
-Boostbutton 3 bar cal
-3 bar Map
-Charge temp sensor
Fuel:
-+40 injectors
-Walbro 255 pump in box, have yet to install
Suspension:
-Monroe sensutrac struts/shocks
-1 coil cut off front springs
-Poly control arm bushings
-AC Delco ball joints
-Polybushings 1-1/4" front and 1-1/8" rear swaybars
Brakes:
-Replaced Brake lines
-Replaced pads/rotors/calipers/master cylinder in 2015
Tires:
-Michelin Defenders
Best ET of 13.8 at 101mph on Michelin defender street tires on ~20psi (with a garrett T2 turbo). I am probably forgetting things, and if I have I will add them in.