View Full Version : Alternate parts thread-OEM to aftermarket-post findings!
Scottmon
12-21-2005, 11:34 AM
Thanks to Simon and others who contributed to the original thread...:D
Post parts you have found that fit TIII's that are from other cars, and aftermarket suppliers.
1.) The front crank seal is CR part #11111,
2.) The cam seals are #14707-CR stands for Chicago Rawhide. You can use these numbers to cross over to any other brand, IE National etc.
3.) Dodge Viper oil cap, I took the gasket off the Viper oil cap and put it on my stocker.
4.) TI/TII/TBI commonblock can be substituted for a trashed TIII block. Grind in the water pump passage area for clearance for the water deflector. Place a core plug in the distributor hole. Crankcase breather can be added by drilling a hole in the distributor core plug and installing breather there (before installing plug!). TBI block will also need to be drilled for turbo oil return on the rear of block.
5.) Substitute thermostat gasket: Use a thermostat gasket from a '94 Dodge 5.2 V8.
6.) Head studs... Acura VTEC B18C1, 11mm. arp part number 208-4303 they are the 11mm ones for the 1.8 vtec. I had to go this route when building my engine because our vendors were out of stock, but everyone and their mothers sell honda parts.
7.) Part numbers through Goodyear for:
Radiator hose, upper 61782
Idler pulley/Serp tensioner pulley's- 49038
Radiator hose, lower 61341
Timing belt 40206
Heater hose, heater to waterpump 63073
Serpentine belt 4060785
Heater hose, heater to engine 63275
Belt numbers for no a/c or UDP.
Stock belt: 060790
Non A/C: 060660
Non A/C & UDP: 060637
I found Dayco belt # 5060670 fit with no a/c, the 60 was too short.
You insert vendors choice for the first number, IE Dayco would be a 5060790, Goodyear a 4060970 etc.
rich tideswell
12-07-2006, 11:42 PM
Category/ Part/ Brand/ Aftermarket Part # / OEM Equivalent
Sensors
Crankshaft Position Sensor:
Borg Warner CSS72
Niehoff AL2024
Camshaft Position Sensor:
Borg Warner CSS74
Oxygen Sensor (4 wire):
Bosch 13275
Fuel Injector (4 total):
GP Sorenson 800-1047N 5277895
Washer Fluid Level Sensor - Front:
Niehoff AL1005
Washer Fluid Level Sensor - Rear:
Niehoff AL1006
Coolant Level Sensor:
Niehoff AL1010
Water Temp. Switch (Gauge):
GP Sorenson TSU113
Ambient Air Temp Sensor (For Overhead Console Cars):
GP Sorenson TSU180
Air Charge Temp Sensor:
Niehoff TS81261
Throttle Position Sensor:
Niehoff FE1088 5234901
Standard TH136 5234901
Knock (Detonation) Sensor:
GP Sorenson KS1 5213629
Borg Warner S799 5213629
Standard KS1 5213629
M.A.P. Sensor:
Niehoff FE-1627 5234327
Standard AS25 5234327
Idle Air Control Valve:
Niehoff 21811 4612159; 4612673; 5277839
Borg Warner 21811 4612159; 4612673; 5277839
Coolant Temperature sensor (2 Pin):
Niehoff TS82231
GP Sorenson TSU110
Coolant Temperature sensor (3 Pin):
GP Sorenson TSU89 4267281
Oil Pressure Switch (Gauge):
GP Sorenson OPS121
Fuel Pressure Regulator:
Niehoff 22823 4306015
Fuel Pump (Assembly Including Pump and Strainer):
Carter P74631H
Fuel Tank Sending Unit (Float Gauge Assembly):
Spectra Premium FG64B
Fuel Tank (Daytona):
Spectra Premium CR2G
Fuel Tank Straps (Daytona):
Spectra Premium ST17
Engine Mounts:
Right Side Motor Mount (Upper Passenger Side) Anchor 2616
Poly Bushings #1000 Note: this mount is polyurethane
Front Motor Mount (Below Radiator on Core Support):
Anchor 2615
Poly Bushings #3419 Note: this mount is polyurethane
Engine Gaskets and Seals
Rear Main Seal :
National 710056 4621939AB, 4667904, MD101915, 4621939, 4667322, 5203590, MD120699
Fel-Pro BS40168-1 Made From Rubber, One Piece
Fel-Pro BS40627 Made From Teflon, One Piece
Timken 710056 Made From Viton, One Piece
Timken 5279 Made From Teflon, One Piece
Intake Manifold Gasket (Plenum Gasket set):
Standard PG34 4343703
Intake Manifold Gasket and Exhaust Manifold Gasket Set:
Mopar 4728214AB
Front Crank Seal:
Chicago Rawhide 11111 4273275
National 3638 4273275
Gates KS11122
Timken 3638
Front Crank Seal Repair Sleeve:
National 99112
Timken KWK99112
Camshaft Seal (2 Required):
Chicago Rawhide 14707 4424059
National 223801 4424059
Gates KS13948
Timken 223801
Camshaft Seal Repair Sleeve (2 Required):
National 99147
Timken KWK99147
Auxiliary Shaft Seal :
National 3655 4105388, 4105389, 4105395, 5203465
Auxiliary Shaft Seal Repair Sleeve:
National 99139
Water Outlet Gasket:
Fel-Pro 35286
Head Gasket:
Mopar 5013602AA
Cometic C5733-65 This is a Multi - Layer Steel - Shim Gasket 0.065 Inches Thick
Valve Cover Gasket (Sold Individually):
Mopar 4484489
Valve Stem Seals (Sold in Set of 16):
Mopar 4424030
Engine Miscelianious
Timing Belt:
Mopar 4667530
Gates T206
Goodyear 40206
Dayco 95206
Head Bolts:
Mopar 6502219
ARP 241-3701 12-Point Head
Head Studs:
ARP 241-4501 Hex Nuts
ARP 241-4701 12-Point Nuts
Main Studs:
ARP 141-5401
Connecting Rod Bolts:
ARP 141-6001 High Performance Complete
ARP 141-6021 High Performance 2 piece
ARP 141-6401 High Performance Wave Complete
Camshaft Sprockets:
FWD Performance FWD 43-0802 Note: These Sprockets are Adjustable and Available in Multiple Colors
Lifters (Set of 16):
FWD Performance fwd 43-0199
Oil Fill Cap:
Stant 10066
Gates 31066
rich tideswell
12-07-2006, 11:50 PM
Electrical
Horn - Low Note:
Niehoff UN451
Horn - Low Note (High Out Put):
Niehoff UN458
Horn - High Note:
Niehoff UN450
Horn - High Note (High Out Put):
Niehoff UN457
Power Window Switch (Driver's Side; 2 Button):
Mopar 4688229
Niehoff MC56591
Dorman 49224
Rear Defogger Switch (Daytona):
Niehoff MC59101
Cruise Control Switch Assembly (Daytona):
Niehoff CC21211
Back-up light Switch:
Niehoff NS37011
Door Jam Switch (Courtesy Lamp Located on A - Pillar):
Niehoff DJ40201
Door Jam Switch (Door Ajar Located on B - Pillar):
Niehoff DJ40211
Head Lamp Switch Assembly (Daytona W/ Fog Lamps):
Niehoff HL20201
Turn Signal Switch:
Niehoff DS50111
Ignition Switch (Daytona):
Niehoff IG69301
Front Windshield Washer Pump:
Niehoff WP7966
Trico 11-514
Dorman 88113
Rear Tailgate Washer Pump:
Trico 11-507
Dorman 88114
Front Windshield Wiper Motor:
Dorman 601-300 Note: This Part is New
Cardone 85-388 Note: This Part is New
Cardone 40-388 Note: This Part is Remanufactured
Rear Windshield Wiper Motor:
Cardone 40-397 Note: This Part is Remanufactured
Turbo
Blow Off Valve:
Mopar 4504564
Heating and Cooling
Water Pump (New):
GMB/ Prestone 120-3060 4626682/ O.E. Casting #4483455
Thermostat:
Prestone 338-192
Bypass Hose (Heater to Engine):
Goodyear L-63275
Gates 18948
Bypass Hose (Heater to Water Pump):
Goodyear 63073
Gates 18075
Bypass Hose (Heater to Oil Cooler):
Gates 18987
Upper Radiator Hose:
Goodyear 61782
Gates 21639
Dayco 71279
Lower Radiator Hose:
Goodyear 61341
Gates 21674
Idler Pulley:
Goodyear 49013
Tensioner Pulley:
Goodyear 49038
Serpentine Belt:
Goodyear 4060785 or 785K6
Gates K060785
Dayco 5060785
Radiator Fan Assembly (Motor Included):
Dorman 620-008
Radiator Fan Motor :
Seimens PM3310
Radiator Cap:
Stant 10231 or 10331 Note: Cap is Rated at 16 PSI
Gates 31516 or 31523 Note: Cap is Rated at 16 PSI
Air Conditioning
A/C Low Pressure Cut-out Switch:
Niehoff HS-30271
A/C Condenser:
Factory Air 54329
A/C Receiver Drier/ Accumulator:
Four Seasons 33550
A/C Evaporator Core:
Four Seasons 54109
A/C Expansion Valve (Block Type Flange):
Four Seasons 38849
A/C Compressor (Remanufactured LTR4, With Clutch):
Four Seasons 57235
Selector Vacuum Switch:
Niehoff HS-30341
Blower Control Switch:
Niehoff HS-80511
Blower Motor:
Siemens PM299
rich tideswell
12-07-2006, 11:57 PM
Engine Filters and Tune-Up
Air Filter:
Fram CA3660
P.C.V. Valve:
Fram FV163
Crankcase Breather Filter:
Fram BA6662
Carbon Canister Filter (4.5in Dia.):
GP Sorenson 779-1000
Ignition Coil:
Wells C939
Spark Plug:
Champion RN12YC Copper
Champion 3405 Platinum
NGK GR4IX Iridium
NGK GR4GP Platinum
NGK GR4 V-Power
Bosch WR8DP Platinum
Splitfire SF6C Copper
Splitfire TP6C Platinum
Spark Plug Wire Set:
Accel 5109R Note: wires set is red
Chassis and Suspension
Power Steering Pressure Hose:
Edelmann 71918
Power Steering Return Hose:
Edelmann 71899
Power Steering Pump:
Cardone 20-863 frim feel stearing code SBA; Note: this part is remanufactured
Power Steering Pump Cap:
Dorman 82577
Power Steering Pressure Sensor:
Niehoff AL9000
Complete Power Steering Pump Rebuild Kit:
Gates 350390
Rear Track Bar Replacement Bushings:
Poly Bushings #1025 Note: this part is polyurethane
Rear shock:
KYB 343164
Rear Axle to Frame Bushings:
Poly Bushings #1036
Front Strut:
KYB 235045
Front Strut Upper Mount with bearing:
Monroe 901908
Front Strut Upper Spring Seat:
Monroe 902993
Front Strut Lower Spring Seat:
Monroe 903980
Front Lower Ball Joint:
TRW 104178
Inner Tie Rod:
TRW ES3061R
Outer Tie Rod End:
TRW ES3008R
Rack and Pinion Assembly:
Cardone 22-336 frim feel stearing code SBA, manual trans, 16inch wheels; Note: this part is remanufacuted
Rack and Pinion Assembly Mounting Bushing:
TRW HB1212
Lower Control Arm Bushings:
TRW HB1750K
Sway Bar Bushing to Control Arm 1" Bar:
TRW HB1806
Sway Bar Bushing to Frame 1" Bar:
TRW HB1620
Sway Bar Bushing to Control Arm 1 1/16" Bar:
TRW HB1807
Sway Bar Bushing to Frame 1 1/16" Bar:
TRW HB1621
Sway Bar Bushing to Control Arm 1 1/8" Bar:
TRW HB1616
Sway Bar Bushing to Frame 1 1/8" Bar:
TRW HB1622
rich tideswell
12-08-2006, 12:11 AM
Brakes
Front Brake Pads; Semi - Metallic:
Raybestos PGD522M
Front Brake Rotor:
Raybestos 7992
Front Brake Caliper - Right:
Reman Parts Inc. 4315 OEM Casting #12391901 ; Note This Part is Remanufactured
Dorman CA10904R O.E.M. #4423716 ; Note: This Part is New
Cardone 18-4362 Supplied With Hardware, Phenolic Piston Supplied Without Mounting Bracket
Cardone 18-B4362 Supplied With Hardware, Phenolic Piston Supplied With Mounting Bracket
Cardone 18-4362S Supplied With Hardware, Metal Piston Supplied Without Mounting Bracket
Cardone 18-B4362S Supplied With Hardware, Metal Piston Supplied With Mounting Bracket
Cardone 16-4362 Supplied With Pads and Hardware Phenolic Piston
Cardone 16-B4362 Supplied With Pads and Hardware Metal Piston
Cardone 15-4362S Supplied With Servre Duty Pads And Hardware Phenolic Piston
Cardone 15-B4362S Supplied With Servre Duty Pads And Hardware Metal Piston
Front Brake Hose With ABS - Right:
Coni - Seal BH177917
Front Brake Caliper - Left:
Reman Parts Inc. 4316 OEM Casting #12391901 ; Note: This Part is Remanufactured
Dorman CA10903L O.E.M. #4423717 ; Note: This Part is New
Cardone 18-4363 Supplied With Hardware, Phenolic Piston Supplied Without Mounting Bracket
Cardone 18-B4363 Supplied With Hardware, Phenolic Piston Supplied With Mounting Bracket
Cardone 18-4363S Supplied With Hardware, Metal Piston Supplied Without Mounting Bracket
Cardone 18-B4363S Supplied With Hardware, Metal Piston Supplied With Mounting Bracket
Cardone 16-4363 Supplied With Pads and Hardware Phenolic Piston
Cardone 16-B4363 Supplied With Pads and Hardware Metal Piston
Cardone 15-4363S Supplied With Severe Duty Pads and Hardware Phenolic Piston
Cardone 15-B4363S Supplied With Severe Duty Pads and Hardware Metal Piston
Front Brake Hose With ABS - Left
Coni - Seal BH177916
Front Brake Caliper Seal Kit - 60mm Piston:
Coni - Seal 66517
Front Brake Caliper Banjo Bolt:
Dorman 13939 Thread: 7/16 x 20; Length: 7/8 inch; Hex Size: 5/8 inch
Front Brake Caliper Slide Bolts:
Carlson H5066 comes in a set of 2 bolts and 2 sleeves
Front Wheel Stud:
Dorman 98480 M12 x 1.5
Rear Brake Pads; Semi - Metallic:
Raybestos PGD415M
Rear Brake Rotor (Vented):
Raybestos 7993
Rear Brake Rotor (Non - Vented):
Raybestos 76002
Rear Brake Caliper - Right (Vented Rotors):
Reman Parts Inc. 4303 OEM Casting #120753
Rear Brake Caliper - Right (Non - Vented Rotors):
Reman Parts Inc. 4301 OEM Casting #120492
Rear Brake Caliper - Left (Vented Rotors):
Reman Parts Inc. 4304 OEM Casting #120753
Rear Brake Caliper - Left (Non - Vented Rotors):
Reman Parts Inc. 4302 OEM Casting #120492
Rear Brake Hose:
Coni - Seal BH177809
Rear Brake Cable - Right:
Raybestos BC93944
Rear Brake Cable - Left:
Raybestos BC93944
Rear Parking Brake Hardware Raybestos:
F138098S
Rear Wheel Stud (Rear Disc Brake Equipped):
Dorman 97045 M12 x 1.5
Wheel Lug Nuts (Chrome Capped) Dorman 98976 M12 x 1.5
Brake Master Cylinder:
Cardone 13-1983 Note: New; Reservoir Included
Cardone 10-1983 Note: this part is remanufactured, no reservior
Power Brake Booster (Remanufactured):
Cardone 54-73172
Stop Light Switch (Daytona):
Niehoff SL-78211
ABS Hydraulic Unit (Remanufactured):
Cardone 12-2107
ABS Control Module:
Cardone 12-1103 5234235
ABS Sensor - Front Right:
Raybestos ABS530348
ABS Sensor - Front Left:
Raybestos ABS530349
ABS Sensor - Rear Right:
Raybestos ABS530080
ABS Sensor - Rear Left:
Raybestos ABS430351
ABS Relay:
Niehoff RL-35491 O.E.M. #4687246
Master Cylinder Cap:
Dorman 42044
Master Cylinder Cap Gasket:
Dorman 42081
Brake Pedal Pad:
Dorman 20727
Spindle Nut - Front :
Dorman *05183
Spindle Nut - Rear
Dorman *05190
Front Hub Assembly:
SKF CBR930013
SKF BR930013
BCA/ National 513075
Timken 513075
Rear Inner Bearing:
BCA/ National A-39
Timken Set46
Rear Outer Bearing:
BCA/ National A-16
Timken Set16 Note: Bearing has Stamping LM12749F, and Race has Stamping LM12711
Rear Inner Seal:
BCA/ National 4099
Timken 4099
Rear Wheel Dust cap:
Dorman 13975
Transmission/ Clutch/ Axle
Manual Transmission Mount (Mid shock tower, driver's side):
Anchor 2618
Poly Bushings #PB2618 Note: this mount is polyurethane
Manual Transmission Bobble Strut:
Poly Bushings #3297 Note: this part is adjustable
Clutch Pedal Pad:
Dorman 20727
Shifter Cable :
Dorman 16653
Clutch Cable:
Raybestos BC94374
Autospecialty CA-83007
Clutch Release Bearing:
Timken 614092
BCA/ National 614092
New Clutch Set:
Fenco NU0066SC
Clutch Fork:
Dorman 14565
Inner Clutch Fork Bearing:
Dorman 14337
Outer Clutch Fork Bearing:
Dorman 14345
Clutch Switch:
Niehoff AL-2500
Differential Bearing (2 Required)
Timken Set11
Differential Bearing Repair Sleeve (2 Required):
Timken KWK99157
Differential Housing Seal:
Timken 3459S
National 3459S
Input Shaft Bearing:
Timken Set4
Input Shaft Seal - Front:
Timken 3732S
Input shaft Seal Repair Sleeve - Front:
Timken KWK99106
Input Shaft Bearing - Rear:
Timken Set5
Axle Shaft - Left Side:
USA Industries AX-65299 Note: This Part is Remanufactured
Cardone 60-3025 Note: This Part is Remanufactured
Cardone 66-3025 Note: this Part is New
Axle Shaft - Right Side
USA Industries AX-65299 Note: This Part is Remanufactured; Equal Length Driveshafts
Cardone 60-3025 Note: This Part is Remanufactured; Equal Length Driveshafts
Cardone 66-3025 Note: This Part is New; Equal Length Driveshafts
USA Industries AX-65309 Note: This Part is Remanufactured; Un-Equal Length Driveshafts
Cardone 60-3034 Note: This Part is Remanufactured; Un-Equal Length Driveshafts
Cardone 66-3034 Note: This Part is New; Un-Equal Length Driveshafts
Inner CV Boot:
Dorman 614-002
Outer CV Boot:
Dorman 614-003
nomadman2001
12-08-2006, 12:16 AM
Nice job Rich! :thumb:
Tony Hanna
05-06-2007, 03:32 PM
GP Sorensen part # CSS40 $38.88 normally stocked (Advance Auto Parts)
It requires cutting the plastic back around the plug, and soldering the pigtail from your old sensor (or a spare HEP... same connector:) ) to the terminals. It also requires filing a flat into the plastic body of the new sensor in the same location as the flat on the stock sensor. Other than that, it's a drop-in replacement. The body is the same length, and the bolt hole is in the right spot.
I just got my Spirit running off of one today, so no long term results yet, but it's working great so far.:thumb:
Maybe someone else can benefit from my experimenting. Sure beats paying $150-$200 for one.:)
Tony Hanna
05-17-2007, 11:55 PM
Paint:
Code PRB Radiant Fire
Duplicolor
1/2 oz bottle/brush (scratch fix) part# NGCC382
5 oz spray can part # DSCC382
1qk4dr
10-07-2009, 09:12 AM
ARP-200-8530 7/16ID 13/16OD BLK WASHER
Is the washer that is used with the ARP Studs
hutwe
07-08-2010, 08:38 AM
4 into 1 vacuum connector on front of block from Dodge. (part# 04504024)
4cefedomni
07-17-2010, 12:33 PM
How is this not in the KC?
Glmwpg
07-03-2011, 03:32 PM
thank you for this post! Great resource wish I had found this years ago!
raccoon
07-03-2011, 04:35 PM
How is this not in the KC?
i second that.
turbovanmanČ
07-09-2011, 07:38 PM
Because its right here in the TIII section, lol. No one checks the KC, but if your here in the TIII section, then you see it, :p
BaxterStockman
02-15-2012, 02:37 PM
At least on my car (1992 Spirit R/T), the power steering pump is NOT Cardone 20-863 firm feel steering - that unit is a Saginaw rebuild, not a ZF. It is Cardone 2040887 (or any of the other part numbers listed on RockAuto), which is unfortunately quite a lot more expensive and also requires sending in the original pump to be rebuilt. I don't know whether Gates 350390 is the correct power steering pump rebuild kit, but I suspect it is, since it's listed on RockAuto as well - so far, for me, RockAuto's been pretty good about getting TIII parts correct (unlike some other suppliers).
EDIT: Well, turns out that Gates 350390 is for the Saginaw, not the ZF. I'll post up the right P/N when I find it.
Powered by vBulletin® Version 4.2.2 Copyright © 2024 vBulletin Solutions, Inc. All rights reserved.